Skip to main content

Using vibrational infrared biomolecular spectroscopy to detect heat-induced changes of molecular structure in relation to nutrient availability of prairie whole oat grains on a molecular basis

Abstract

Background

To our knowledge, there is little study on the interaction between nutrient availability and molecular structure changes induced by different processing methods in dairy cattle. The objective of this study was to investigate the effect of heat processing methods on interaction between nutrient availability and molecular structure in terms of functional groups that are related to protein and starch inherent structure of oat grains with two continued years and three replication of each year.

Method

The oat grains were kept as raw (control) or heated in an air-draft oven (dry roasting: DO) at 120 °C for 60 min and under microwave irradiation (MIO) for 6 min. The molecular structure features were revealed by vibrational infrared molecular spectroscopy.

Results

The results showed that rumen degradability of dry matter, protein and starch was significantly lower (P <0.05) for MIO compared to control and DO treatments. A higher protein α-helix to β-sheet and a lower amide I to starch area ratio were observed for MIO compared to DO and/or raw treatment. A negative correlation (−0.99, P < 0.01) was observed between α-helix or amide I to starch area ratio and dry matter. A positive correlation (0.99, P < 0.01) was found between protein β-sheet and crude protein.

Conclusion

The results reveal that oat grains are more sensitive to microwave irradiation than dry heating in terms of protein and starch molecular profile and nutrient availability in ruminants.

Background

Nowadays, there is high demand for the development of highly productive animals and as a result the energy and protein availability from the feed need to be increased. To meet this request, cereal grains (i.e., oat, barley) are generally fed to ruminant in order to increase the nutrient density of diet. On the other hand, a problem remains, the rapidly and extensively degradation of their starch and protein in the rumen. This may cause serious digestive disorders and nutritional imbalance, which may also result in nitrogen loss and inefficient use of dietary energy [15]. To improve the utilization of cereal grains and the availability of their nutrients, heat treatments have been used [1, 610]. Although heat treatments are commonly used during the processing of cereal grains, just few research studies exist on how heat treatments would affect their nutrient molecular structures and utilization interaction by ruminants. The investigation of molecular structure that are related to protein and starch is often crucial to understand their digestive behaviour, nutritive quality, and availability in ruminants [6, 7, 11, 12]. Oat grains (Avena sativa L.) are a good source of protein, unsaturated fatty acids, and phenolic compounds as well as dietary fibre and starch. Although oats have a slightly lower energy range than most of the other grains, they have high fibre content, and are considered a safer grain to feed ruminants than either wheat or barley [13, 14].

Fourier-transformed infrared-vibration spectroscopy is capable to detect structure features on a molecular basis, including protein, carbohydrate, lipid related functional groups [1]. However, to our knowledge, there is few study on the interaction between nutrient availability and molecular structure changes induced by different processing methods in dairy cattle [1519]. The objective of this study was to investigate whether molecular structures that are related to protein and starch are highly affected by different heat processing methods using attenuated total reflectance-Fourier-transformed infrared-vibration spectroscopy (ATR-FT/IR) [20], and to study the heat-induced changes in nutrient profile and availability in relation to molecular structure changes in ruminants. The results of this study will allow us to select the most suitable heat processing method for oat cereal grains, in order to increase their efficiency for ruminants.

Methods

Animal trails were approved by the University of Saskatchewan Animal Research Ethics Board (AREB) with ANIMAL USE PROTOCOL # 19910012 and were conducted in accordance with the Canadian Council of Animal Care guidelines in 1993 [21].

Oat seed processing method

Oat grains (Avena sativa L. cv. ‘CDC Dancer), harvested in two different years were used for feed protein study and obtained from the Crop Development Centre, University of Saskatchewan, Canada. For heating processing 1 kg of oat grains was roller milled through 0.20 mm dies, divided into 3 portions and allowed for 3 different treatments. Control sample (RO) was kept raw. Dry heated sample (DO) was heated in an air-draft oven at 120 °C for 60 min. Microwave irradiated sample (MIO) was heated in a microwave oven for 6 min in which sample was taken out intermittently and mixed in every 2 min.

ATR-FT/IR molecular spectroscopy

Each oat seed sample were finely ground using a fit with a 0.5 mm screen. The molecular spectral data of oat seed were collected and corrected with the background spectrum using Jasco ATR-FT/IR 4200 (Jasco Inc., Easton, MD Corp., Tokyo, Japan). The spectra were generated with mid-IR (ca. 4,000–800 cm−1) and fingerprint region (ca. 1,800–800 cm−1) with spectral resolution of 4 cm−1. The ATR-FT/IR spectral data were analysed using OMNIC 7.3 (Spectra-Tech Inc., Madison, WI) software. Chemical functional groups were identified according to published results [11]. The regions of specific interest in this present study included the protein amide I, II, and protein structure of α-helix and β-sheet and starch in the IR regions of approximately 1,715–1,480 cm−1 and 949–1,062 cm−1, respectively. The ratios of amide I and II, α-helix and β-sheet and amide I and starch spectral intensities were calculated.

Rumen degradation

For the rumen degradation study, the standard Dept in situ method was applied with dry Holstein cows with flexible rumen cannula (10 cm i.d.; Bar Diamond Inc., Parma, ID, USA). The animals were housed in the research barn at the University of Saskatchewan. The cows were given ad libitum access to water and 15 kg (as fed) of a totally mixed ration (TMR) twice daily (7.5 kg/feeding) at 0800 and 1600 h, formulated to meet or exceed NRC requirements [22]. Seven grams of an individual ground sample were weighed into each pre-weighed and numbered nylon bag (10 cm × 20 cm; Nitex 03-41/31 monofilament open mesh fabric, Screentec Corp., Mississauga, ON) with the pore size of 40 μm. These bags were tied about 2 cm below the top, allowing a ratio of sample size to bag surface area of 19 mg/cm2. Samples were incubated in the rumen for 16 h in dry Holstein cows with two runs. After the incubation, the bags were removed from the rumen and rinsed under a cold stream of tap water without detergent to stop microbial enzymatic degradation and remove the adhering ruminal contents. Subsequently the bags were dried at 55 °C for 48 h and reweighed to complete the calculation. The dried samples were kept in a refrigerated room (4 °C) until needed for chemical analysis.

Chemical analyses

The residues collected from the nylon bags were transferred into labelled containers and ground through a 1 mm screen (Retsch ZM-1; Brinkmann Instruments, Mississauga, ON) for analysis, with the exception of the starch analysis where samples were ground through a 0.5 mm screen. Samples were analysed for dry matter (DM), ash and crude protein (CP) content according to the AOAC [23]. Starch content was analysed using the Megazyme Total Starch Assay Kit (Megazyme International Ltd., Bray, Wicklow, Ireland) based on thermostable α-amylase/amyloglucosidase [24].

Intestinal protein digestibility

Intestinal protein digestibility (IVCPD) was determined according to the modified in vitro method of Calsamiglia and Stern [2527]. Briefly, dried ground rumen residues containing 15 mg of N after 16 h of ruminal incubation were exposed for 1 h to 10 mL of 0.1 N HCl solution containing 1 g of pepsin/L. The pH was then neutralized with 0.5 mL of 0.5 mol NaOH/L and 13.5 mL of pH 7.8 phosphate buffer containing 37.5 mg of pancreatin, which were added to the solution and incubated at 38 °C for 24 h. After 24 h of incubation, 3 mL of a 100 % (w/v) trichloroacetic acid solution was added to precipitate undigested proteins. The samples were centrifuged, and the supernatant was analysed for N (Kjeldahl method, AOAC 984.13). Intestinal digestion of protein was calculated as TCA-soluble N divided by the amount of N in the 16 h residue sample.

Statistical analysis

Statistical analyses of the chemical, nutrition and spectral data were performed using the MIXED procedure of SAS (version 9.3). The model used for the chemical and spectral (amide I, II, beta-sheet, alpha-helix, and their ratios etc.), studies was: Yijk = μ + Ti + Yj + eijk. The model used for the rumen and intestinal digestion studies was: Yijk = μ + Ti + Yj + Rj + eijk, where, Yij was an observation of the dependent variable ij; μ was the population mean for the variable; Ti was the fixed effect of heat treatment (raw, dry roasting, microwave irradiation), Yj and Ri were the random year and cows effects, respectively, and eij and eijk were the random errors associated with the observation ijk. Tukey method was used for mean separations. Significant level was declared at P < 0.05

Results

Chemical composition and nutrient availability

Chemical profiles and nutrient availability of raw and heat processed oat seeds (DO and MIO) are presented in Table 1. Significant differences among the treatments for nutrients content were observed except crude protein (P > 0.05). Compared with the control (raw), dry roasting did not significantly increased the DM content, while its value was lower than that for the MIO treatment (P < 0.05). The MIO resulted in a higher starch content compared to the raw (P < 0.05). The in situ nutrient rumen degradation of oat seeds affected significantly by microwave irradiation. The feed rumen residue after 16 h of incubation was higher for the MIO treatment compared to the DO or the raw. The protein intestinal digestibility (Table 1) tended to be affected by heat treatment, while the value obtained for the MIO treatment was higher (P < 0.05) and tended to be higher (P <0.10) than that of the Raw and DO, respectively

Table 1 Chemical profiles and nutrient availability: comparison among raw (RO), dry roasted (DO) and microwave irradiation (MIO) oat seed

Heat-induced changes in molecular structure characteristics

Results from the molecular structure analyses that are related to protein and starch is shown in Table 2. In the present study, the microwave irradiation decreased (P < 0.05) the ratio of α-helix to β-sheet, the amide I and II height, the α-helix, β-sheet, and the amide I to starch area ratios compared with the raw (control). It means that the microwave irradiation increased the ratio of β-sheet to α-helix.

Table 2 Molecular structure spectral characteristics using ATR-FT/IR molecular spectroscopy: comparison among raw (RO), dry roasted (DO) and microwave irradiation (MIO) oat seed

Correlations between protein and starch structure characteristics and nutrient profiles

Correlations between protein and starch molecular structure characteristics and nutrient profiles of oat seeds are presented in Table 3. Crude protein found to be positive correlated (R = −0.99, P <0.05) with the β-sheet while dry matter was negatively correlated with the ratio amide I to starch area (R = −0.99, P < 0.05). The IVCPD was also negatively correlated with α-helix (R = −0.99, P <0.01) and ratio of amide I to starch area (R = −0.99, P <0.05).

Table 3 Correlation between molecular structures (amide I, amide II, their ratio and amide I and starch ratio) and nutrient profiles of processed oat seed

Discussion

In the present study, compared with the control, dry roasting significantly increased the DM content, indicating that dry treatment decreased the moisture holding capacity of oat seeds. Moreover, the crude protein content did not affected by any heat treatment in accordance with earlier findings [610]. Concerning starch, although it plays an important role in the processing of oat based feeds and is an important component of the its grain, the effect of heat treatments on oat starch structure properties is poorly characterized in current literature. The total starch content in our oat samples was affected by each of the heat treatment used, and was in the range that is typically found in oats [28].

The results based the chemical profile and nutrient degradability changes, indicated that the susceptibility of oat seeds to heating methods was distinct. Microwave irradiation was more efficient in altering the protein profile and influences the nutrient ruminal degradability (i.e., nutrient residue) than the dry roasting. The increase of the feed residue after rumen incubation and at the same time the increase in intestinal digestibility of rumen undegradable protein with microwave irradiation can be related to the shift in protein subfractions [7].

No differences found between the raw and the dry roasted seeds on the IVCPD in accordance with Samadi and Yu [7] on soybeans. One possible reason for this is that the temperature or the time for the treatments was not sufficient in order to damage the oat seed protein, and so let any differences estimation using a protocol by Calsamiglia and Stern [25], to be detected. As stated previously by Stern et al. [29], heating above the optimal temperature may overprotect the protein, so that the protein is neither fermented in the rumen nor digested in the small intestine.

Our research study explored the molecular structure related to protein and starch and the effect of heat treatments on their profile. Heat processing reduces protein degradation in the rumen and optimizes protein utilization in ruminants by changing protein molecular structures, such as denaturation, unfolding or uncoiling of a coiled or pleated structure, or the separation of the protein into its subunits, which may then unfold or uncoil [1, 11, 17]. The heat-induced changes in inherent protein structures, (i.e., the ratios of amide I to amide II area, α-helix to β-sheet) affect the rumen and intestinal digestibility of protein by changing protein solubility [6], and the access of microbes and proteolytic enzymes to protein molecules in the gastrointestinal tract of dairy cattle [11, 18]. Even if feeds contain similar protein contents, their nutritive value may be different if the α-helix-to-β-sheet ratios of their protein secondary structures are different [7]. In our study, α-helx and the ratio of α-helix to β-sheet were affected by the heat process and this alteration in the protein structure ratio was probably caused by denaturation of α-helices and β-sheets during the heat treatment.

Moreover compared to control seeds (raw) dry roasting did not affect the protein secondary structure profile in contrast with the results found by Yu [16] on flaxseed. They concluded that dry heating decreased the percentage of α-helix (from 47.1 to 36.1 %), increased the percentage of β-sheet (from 37.2 to 49.8 %), and decreased the α-helix-to-β-ratio. Similar results with our study mentioned by Peng et al. [8] on camelina seeds where, dry heating did not change any of their measured spectral characteristics associated with protein structure compared with raw seeds.

On the other hand, thermal properties of starch play an important role in feed processing and are highly dependent on the starch structure, specifically, the amylose and amylopectin ratio [30]. So, since the physicochemical and digestibility properties of starch are influenced by the starch structure, it would be interesting to know how the heat treatments affect these parameters in oat starch. So, we found that only the ratio amide I to starch area affected by heat processing.

Conclusion

The results reveal that oat seed is more sensitive to microwave irradiation than dry heating in terms of protein and starch molecular profile and nutrient availability in ruminants.

References

  1. Yu P. Protein molecular structures, protein subfractions, and protein availability affected by heat processing: a review. Am J Biochem Biotechnol. 2007;3:70–90.

    Article  Google Scholar 

  2. Nuez-Ortín WG, Yu P. Effects of bioethanol plant and Co-products type on the metabolic characteristics of the proteins. J Dairy Sci. 2010;93:3775–83.

    Article  PubMed  Google Scholar 

  3. Damiran D, Yu P. Molecular basis of structural makeup of hulless barley in relation to rumen degradation kinetics and intestinal availability in dairy cattle: a novel approach. J Dairy Sci. 2011;94:5151–9.

    Article  CAS  PubMed  Google Scholar 

  4. Gamage IH, Yu P. Short communication: comparison of newly developed DVE/OEB2010 system and NRC2001 model in modeling metabolic characteristics of proteins. J Dairy Sci. 2013;96:5908–13.

    Article  CAS  PubMed  Google Scholar 

  5. Gamage IH, Jonker A, Christensen DA, Yu P. Metabolic characteristic of proteins and biomolecular spectroscopic profiles in different batches of feedstock (Wheat) and their Co-products (Wheat Dried Distillers Grain with Solubles) from the same bioethanol processing plant. J Dairy Sci. 2012;95:6695–715.

    Article  CAS  PubMed  Google Scholar 

  6. Doiron K, Yu P, McKinnon JJ, Christensen DA. Heat induced protein structure and subfractions in relation to protein degradation kinetics and intestinal availability in dairy cattle. J Dairy Sci. 2009;92:3319–30.

    Article  CAS  PubMed  Google Scholar 

  7. Samadi, Yu P. Dry and moist heating-induced changes in protein molecular structure, protein subfraction, and nutrient profiles in soybeans. J Dairy Sci. 2011;94:6092–102.

    Article  CAS  PubMed  Google Scholar 

  8. Peng Q, Khan NA, Wang Z, Yu P. Moist and dry heating-induced changes in protein molecular structure, protein subfractions, and nutrient profiles in camelina seeds. J Dairy Sci. 2014;97:446–57.

    Article  CAS  PubMed  Google Scholar 

  9. Huang X, Khan NA, Zhang X, Yu P. Effects of canola meal pellet conditioning temperature and time on ruminal and intestinal digestion, hourly effective degradation ratio, and potential N to energy synchronization in dairy cows. J Dairy Sci. 2015;98:8836–45.

    Article  CAS  PubMed  Google Scholar 

  10. Huang X, Christensen C, Yu P. Effects of conditioning temperature and time during the pelleting process on feed molecular structure, pellet durability index, metabolic features of Co-products from Bio-Oil processing in dairy cows. J Dairy Sci. 2015;98:4869–81.

    Article  CAS  PubMed  Google Scholar 

  11. Theodoridou K, Yu P. Application potential of ATR-FT/IR molecular spectroscopy in animal nutrition: Revelation of protein molecular structures of canola meal and presscake, as affected by heat-processing methods, in relationship with their protein digestive behavior and utilization for dairy cattle. J Agric Food Chem. 2013;61:5449–58.

    Article  CAS  PubMed  Google Scholar 

  12. Becker PM, Yu P. What makes protein indigestible from tissue, cellular and molecular structure aspects? Mol Nutr Food Res. 2013;57:1695–707.

    CAS  PubMed  Google Scholar 

  13. Zhang X, Yu P. Differentiation of mixtures of co-product blend with barley grain based on Fourier transform infrared attenuated total reflection molecular spectroscopy: Carbohydrate molecular structure spectral profiles and nutritive characteristics in dairy cattle. J Dairy Sci. 2012;95:6624–34.

    Article  CAS  PubMed  Google Scholar 

  14. Zhang X, Yu P. Molecular basis of protein structure in combined feeds (hulless barley with bioethanol coproduct of wheat dried distillers grains with solubles) in relation to protein rumen degradation kinetics and intestinal availability in dairy cattle. J Dairy Sci. 2012;95:3363–79.

    Article  CAS  PubMed  Google Scholar 

  15. Yu P. Application of advanced synchrotron radiation-based Fourier transform infrared (SR-FTIR) microspectroscopy to animal nutrition and feed science: a novel approach. Br J Nutr. 2004;92:869–85.

    Article  CAS  PubMed  Google Scholar 

  16. Yu P. Protein secondary structures (α-helix and β-sheet) at a cellular level and protein fractions in relation to rumen degradation behaviours of protein: a new approach. Br J Nutr. 2005;94:655–65.

    Article  CAS  PubMed  Google Scholar 

  17. Yu P. Plant-based food and feed protein structure changes induced by gene-transformation, heating and bio-ethanol processing: a synchrotron-based molecular structure and nutrition research program. Mol Nutr Food Res. 2010;54:1535–45.

    Article  CAS  PubMed  Google Scholar 

  18. Yu P, Nuez-Ortin WG. Relationship of protein molecular structure to metabolisable proteins in different types of dried distillers grains with solubles: a novel approach. Br J Nutr. 2010;104:1429–37.

    Article  CAS  PubMed  Google Scholar 

  19. Yu P. Short communication: Relationship of Carbohydrate Molecular Spectroscopic Features to Carbohydrate Nutrient Profiles in Co-Products from Bioethanol Production. J Dairy Sci. 2012;95:2091–6.

    Article  CAS  PubMed  Google Scholar 

  20. Yu P. Applications of hierarchical cluster analysis (CLA) and principal component analysis (PCA) in feed structure and feed molecular chemistry research, using synchrotron-based Fourier transform infrared (FTIR) microspectroscopy. J Agric Food Chem. 2005;53:7115–27.

    Article  CAS  PubMed  Google Scholar 

  21. Canadian Council on Animal Care. Guide to the Care and Use of Experimental Animals, vol. 1. Ottawa: CCAC; 1993.

    Google Scholar 

  22. NRC. Nutrient Requirements of Dairy Cattle. 7th ed. Washington, DC: National Academies Press; 2001.

    Google Scholar 

  23. AOAC. Officials methods of analysis. 15th ed. Arlington: Association of Official analytical Chemists; 1990.

    Google Scholar 

  24. McCleary BV, Gibson TS, Mugford DC. Measurement of total starch in cereal products by amyloglucosidase-α-amylase method: Collaborative study. J AOAC Intl. 1997;80:571–9.

    CAS  Google Scholar 

  25. Calsamiglia S, Stern MD. A three-step in vitro procedure for estimating intestinal digestion of protein in ruminants. J Anim Sci. 1995;73:1459–65.

    Article  CAS  PubMed  Google Scholar 

  26. Heendeniya RG, Christensen DA, Maenz DD, McKinnon JJ, Yu P. Protein fractionation by-products from Canola meal for dairy cattle. J Dairy Sci. 2012;95:4488–500.

    Article  CAS  PubMed  Google Scholar 

  27. Abeysekara S, Christensen DA, Niu Z, Theodoridou K, Yu P. Molecular structure, chemical and nutrient profiles and metabolic characteristics of the proteins and energy in New cool-season corn cultivars harvested as fresh forage for dairy cattle. J Dairy Sci. 2013;96:6631–43.

    Article  CAS  PubMed  Google Scholar 

  28. Ovando-Martínez M, Whitney K, Reuhs BL, Doehlert DC, Simsek S. Effect of hydrothermal treatment on physicochemical and digestibility properties of oat starch. Food Res Int. 2013;52:17–25.

    Article  Google Scholar 

  29. Stern MD, Santos KA, Satter LD. Protein degradation in rumen and amino acids absorption in the small intestine of lactating dairy cattle fed heat-treated whole soybeans. J Dairy Sci. 1985;68:45–56.

    Article  CAS  PubMed  Google Scholar 

  30. Jane J, Chen Y, Lee LF, McPherson AE, Wong KS, Radosavljevic M, Kasemsuwa T. Effects of amylopectin branch chain length and amylose content on the gelatinization and pasting properties of starch. Cereal Chem J. 1999;76:629–37.

    Article  CAS  Google Scholar 

Download references

Acknowledgement

The authors would like to thank Zhiyuan Niu for technical assistance.

Funding

This research has been supported by grants from the Prairie Oat Grower Association (POGA), Natural Sciences and Engineering Research Council of Canada (NSERC- federal government), and Ministry of Agriculture Strategic Research Chair (PY) Program.

Availability of data and materials

The datasets during and/or analyzed during the current study available from the corresponding author on reasonable request.

Authors’ contributions

MR was a PhD student and KT was PDF research fellow. PY was supervisor, PI and designed the study. MR and KT carried out the experiments and measurements. KT trained MR as daily supervisor and wrote the manuscript together. The authors read and approved the final manuscript.

Competing interests

The authors declare that they have no competing interest.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Peiqiang Yu.

Rights and permissions

Open Access This article is distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Rahman, M.D.M., Theodoridou, K. & Yu, P. Using vibrational infrared biomolecular spectroscopy to detect heat-induced changes of molecular structure in relation to nutrient availability of prairie whole oat grains on a molecular basis. J Animal Sci Biotechnol 7, 52 (2016). https://doi.org/10.1186/s40104-016-0111-y

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/s40104-016-0111-y

Keywords